EXPERIMENTAL STUDY ON THE SHEAR STRENGTH AND DEFORMATION CHARACTERISTICS OF LIGNIN-FIBER RED CLAY
-
摘要: 利用工业废料改良土体性能不仅具有实用价值而且能够保护环境。采用室内土工试验及SEM试验，针对木质素纤维加筋红黏土的效果，以及木质素纤维掺量对红黏土强度及变形特性的影响规律和作用机理进行研究。试验结果表明：木质素红粘土压缩模量随着纤维掺量的增加先增加后减小，2%纤维掺量时，模量最高；不同木质素掺量红粘土的内摩擦角基本保持不变；红黏土黏聚力随木质素掺量的增加先减小后增大再减小。2%是纤维最优掺量，土体黏聚力出现最大值；在三轴实验中，加筋红黏土试样均发生鼓胀变形，没有明显的破裂面，具有典型的应变硬化特征。研究结果表明木质素纤维能一定程度提高红粘土的强度，提升红粘土的工程应用价值。Abstract: The pollution of geomaterials is one of the key problems in construction. Considering proportion of lignin fibre, laboratory mechanics experiments and SEM tests were applied to natural red clay and lignin fibre-adding red clay. Variation laws of strength characteristics and effects were studied when added volumes were various. The results showed that:lignin fibre could enhance the compression modulus of red clay under different press levels and the results appeared regularly changing; cohesive strength of red clay increased first then decrease with the increase of lignin fibre. Interlock forces that formed between lignin fibre and soil particle were less than joint force existing in skeletal structure of natural red clay, which could not enhance the soil strength when mixing amount was under 1%. Cohesive strength showed maximum, but the internal friction angle remained stable when the mixing amount was 2%; stressed red clay containing lignin fibre showed bulging deformation without obvious fracture surface. Hence, tension failure and adhering failure didn't exist in red clay containing lignin fibre and presented typical properties of strain hardening; red clay containing lignin fibre could enhance the residual strength effectively.
-
Key words:
- red clay /
- lignin-fiber /
- triaxial compression test /
- shear strength /
- fiber content
-
图 3 不同掺量下红黏土压缩模量
Figure 3. The compression modulus of red clay under different dosages
图 4 不同围压下应力-应变关系曲线
Figure 4. Stress-strain relation curves under different confining pressures
图 7 纤维表面扫描电镜照片(放大1200倍)
Figure 7. Scanning electron microscope images of fiber surface (magnified 1200 times)
图 8 各围压下木质素纤维红黏土试验破损形态
Figure 8. Test failure patterns of lignin-fibrous red clay under different confining pressures
表 1 红黏土的物理性质指标
Table 1. Physical properties of red clay
物理参数 值 天然含水率ω/% 66 天然密度ρ/(g·cm-3) 1.70 塑限ωP/% 48.6 液限ωL/% 82 比重γ/(g·cm-3) 2.67 
下载: 导出CSV
表 2 木质素纤维物理性质参数
Table 2. Physical properties of lignin-fibers
纤维参数 值 纤维长度/mm 6~8 灰分含量/% 18±5 pH值 7.5±1 含水率/% ＜5 耐热能力/℃ 230
下载: 导出CSV
表 3 三轴压缩试验强度指标
Table 3. Triaxial compression test strength index
纤维掺量/% 抗剪强度指标 主应力差(σ1-σ3)/kPa 黏聚力c/kPa 内摩擦角φ/(°) 围压50/kPa 围压100/kPa 围压200/kPa 围压300/kPa 围压400/kPa 0 24.9 15.8 118 149.6 227.7 322.4 366.1 1 20.1 15.6 94.9 158.2 192.9 284.5 344.5 1.5 34.9 15.2 128.3 169.5 228.6 287.4 386.9 2 36.7 16.5 139.9 176.4 241.8 348.8 396.9 2.5 31.3 16.2 130.5 172.9 229.5 334.8 377.3 3 18.9 15.4 120.3 169.1 222.2 322.8 348.8
下载: 导出CSV
-
[1] 廖义玲.贵州碳酸盐岩红土[M].贵州:贵州人民出版社, 2003.LIAO Yiling. Guizhou carbonate red clay[M]. Guizhou:Guizhou People's Publishing House, 2003. (in Chinese) [2] 刘之葵, 陈逸方, 邱晓娟.不同酸碱度对改良红黏土力学性质及结构的影响[J].人民长江, 2016, 47(16):77-82. http://d.old.wanfangdata.com.cn/Periodical/rmcj201616018LIU Zhikui, CHEN Yifang, QIU Xiaojuan. Research on mechanical properties and microstructure of improved Guilin red clay under different pH environment[J]. People's Yangtze River, 2016, 47(16):77-82. (in Chinese with English abstract) http://d.old.wanfangdata.com.cn/Periodical/rmcj201616018 [3] 王海湘, 张金团, 于冬升. CaCO3与砂改良高液限红黏土对比试验研究[J].江西理工大学学报, 2016, 37(3):31-35. http://d.old.wanfangdata.com.cn/Periodical/nfyjxyxb201603006WANG Haixiang, ZHANG Jinyuan, YU Dongsheng. Research on comparative tests of CaCO3 and sand improved high liquid limit red clay[J]. Journal of Jiangxi University of Science and Technology, 2016, 37(3):31-35. (in Chinese with English abstract) http://d.old.wanfangdata.com.cn/Periodical/nfyjxyxb201603006 [4] 刘建龙, 侯天顺, 骆亚生.棉纤维加筋土无侧限抗压强度试验研究[J].水力发电学报, 2018, 37(2):12-21. http://d.old.wanfangdata.com.cn/Periodical/slfdxb201802002LIU Jianlong, HOU Tianshun, LUO Yasheng. Unconfined compressive strength of synthetic cotton fibers reinforced soil[J]. Journal of Hydraulic Power Generation, 2008, 37(2):12-21. (in Chinese with English abstract) http://d.old.wanfangdata.com.cn/Periodical/slfdxb201802002 [5] ZHANG T, LIU S Y, CAI G J, et al. Study on strength characteristics and microcosmic mechanism of silt improved by lignin-based bio-energy coproducts[J]. Ground Improvement and Geosynthetics, 2014, 238:220-230. http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=CC0214527568 [6] 祝烨.植物纤维在不同实际工程中的研究应用[J].四川建材, 2018, 44(1):116, 130. doi: 10.3969/j.issn.1672-4011.2008.01.053ZHU Ye. Research and application of plant fiber in different practical projects[J]. Sichuan Building Materials, 2008, 44(1):116, 130. (in Chinese) doi: 10.3969/j.issn.1672-4011.2008.01.053 [7] 杨俊, 刘世宜, 张国栋.初始干密度对天然砂砾改良红粘土回弹模量的影响及预估模型[J].土木建筑与环境工程, 2016, 38(2):21-28. http://d.old.wanfangdata.com.cn/Periodical/cqjzdxxb201602003YANG Jun, LIU Shiyi, ZHANG Guodong. Impact and prediction model of initial dry density on resilient modulus of gravel soil red clay[J]. Journal of Civil, Architecture & Environmental Engineering, 2016, 38(2):21-28. (in Chinese with English abstract) http://d.old.wanfangdata.com.cn/Periodical/cqjzdxxb201602003 [8] 刘旸, 陈开圣, 吕梦飞, 等.干湿循环下红黏土边坡响应的模型试验[J].水利水电技术, 2018, 49(8):193-203. http://d.old.wanfangdata.com.cn/Periodical/slsdjs201808026LIU Yang, CHEN Kaisheng, LV Mengfei, et al. Model experiment of response of red clay slope under dry-wet cycle[J]. Water Resources and Hydropower Engineering, 2018, 49(8):193-203. (in Chinese with English abstract) http://d.old.wanfangdata.com.cn/Periodical/slsdjs201808026 [9] 张金利, 蒋正国, 杨钢.聚丙烯纤维红黏土力学特性试验研究[J].岩土工程学报, 2011, 33(S1):420-425. http://d.old.wanfangdata.com.cn/Conference/7507926ZHANG Jinli, JIANG Zhengguo, YANG Gang. Experimental study on mechanical behaviors of polypropylene fiber reinforced clay[J]. Journal of Geotechnical Engineering, 2011, 33(S1):420-425. (in Chinese with English abstract) http://d.old.wanfangdata.com.cn/Conference/7507926 [10] 万友元, 彭学先.玻璃纤维和石灰对红黏土压缩特性影响的试验研究[J].公路工程, 2017, 42(4):281-284, 293. http://d.old.wanfangdata.com.cn/Periodical/znglgc201704057WAN Youyuan, PENG Xuexian. Experimental study on compression properties of glass fiber and lime reinforced red clay[J]. Highway Engineering, 2014, 42(4):281-284, 293. (in Chinese with English abstract) http://d.old.wanfangdata.com.cn/Periodical/znglgc201704057 [11] 赵宁雨, 荆林立.纤维加筋红黏土强度特性影响因素的试验[J].重庆理工大学学报(自然科学), 2010, 24(9):47-51, 68. http://d.old.wanfangdata.com.cn/Periodical/cqgxyxb201009010ZHAO Ningyu, JING Linli. Experimental study on strength properties of Texsol[J]. Journal of Chongqing University of Technology (Natural Science), 2010, 24(9):47-51, 68. (in Chinese with English abstract) http://d.old.wanfangdata.com.cn/Periodical/cqgxyxb201009010 [12] 窦远明, 王建宁, 朱旭曦, 等.软弱土质类相似材料的配比试验结果分析[J].水利水电技术, 2017, 48(5):128-135. http://d.old.wanfangdata.com.cn/Periodical/slsdjs201705020DOU Yuanming, WANG Jianning, ZHU Xuxi, et al. Analysis of results of the mixture ratio test of soft soil similar material[J]. Water Resources and Hydropower Engineering, 2017, 48(5):128-135. (in Chinese with English abstract) http://d.old.wanfangdata.com.cn/Periodical/slsdjs201705020 [13] 尤波, 徐洪钟, 董金梅.玄武岩纤维加筋膨胀土三轴试验研究[J].防灾减灾工程学报, 2015, 35(4):503-507, 514. http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=dzxk201504013YOU Bo, XU Hongzhong, DONG Jinmei. Triaxial tests of expansive soil reinforced with basalt fibe[J]. Journal of Disaster Prevention and Mitigation Engineering, 2015, 35(4):503-507, 514. (in Chinese with English abstract) http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=dzxk201504013 [14] 王德银, 唐朝生, 李建, 等.纤维加筋非饱和黏性土的剪切强度特性[J].岩土工程学报, 2013, 35(10):1933-1940. http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=ytgcxb201310024WANG Deyin, TANG Chaosheng, LI Jian, et al. Shear strength characteristics of fiber-reinforced unsaturated cohesive soils[J]. Journal of Geotechnical Engineering, 2013, 35(10):1933-1940. (in Chinese with English abstract) http://www.wanfangdata.com.cn/details/detail.do?_type=perio&id=ytgcxb201310024 [15] 张岩, 耿济世, 毛磊.珠江三角洲海相沉积软土压缩和剪切变形特性试验研究[J].地震工程学报, 2018, 40(04):745-751. doi: 10.3969/j.issn.1000-0844.2018.04.745Zhang Yan, Yan Jishi, Mao Lei. Compression and shear deformation properties of marine soft soil deposits in the pearl river delta[J]. Journal of Earthquake Engineering, 2018, 40(4):745-751. (in Chinese with English abstract) doi: 10.3969/j.issn.1000-0844.2018.04.745 [16] 周志国, 张云雁, 符必昌, 等.昆明长水国际机场砂页岩残积红土动力特性研究[J].地质力学学报, 2018, 24(6):795-802, doi:10.12090/j.issn.1006-6616.2018.24.06.082.ZHOU Zhiguo, ZHANG Yunyan, FU Bichang. A study on dynamic characteristics of sandshale eluvial laterite at Kunming Changshui International Airport[J]. Journal of Geomechanics, 2018, 24(6):795-802, doi:10.12090/j.issn.1006-6616.2018.24.06.082.Chinese with English abstract [17] 唐朝生, 施斌, 高玮, 等.纤维加筋土中单根纤维的拉拔试验及临界加筋长度的确定[J].岩土力学, 2009, 30(8):2225-2230. doi: 10.3969/j.issn.1000-7598.2009.08.004TANG Chaosheng, SHI Bin, GAO Wei, et al. Single fiber pull-out test and the determination of critical fiber reinforcement length for fiber reinforced soil[J]. Geotechnical mechanics, 2009, 30(8):2225-2230. (in Chinese with English abstract) doi: 10.3969/j.issn.1000-7598.2009.08.004 [18] 高磊, 胡国辉, 陈永辉, 等.玄武岩纤维加筋黏土三轴试验研究[J].岩土工程学报, 2017, 39(S1):198-203. http://d.old.wanfangdata.com.cn/Periodical/ytgcxb2017z1040GAO Lei, HU Guohui, CHEN Yonghui, et al. Triaxial tests clay reinforced by basalt fiber[J]. Chinese Journal of Geotechnical Engineering, 2013, 39(S1):198-203. (in Chinese with English abstract) http://d.old.wanfangdata.com.cn/Periodical/ytgcxb2017z1040 [19] 胡达.纤维素纤维加筋土的力学特性[J].公路交通科技, 2018, 35(1):22-27, 35. http://d.old.wanfangdata.com.cn/Periodical/gljtkj201801004HU Da. Mechanical property of cellulose fiber reinforced clay[J]. Journal of Highway and Transportation Research and Development, 2011, 35(1):22-27, 35. (in Chinese with English abstract) http://d.old.wanfangdata.com.cn/Periodical/gljtkj201801004 -
下载:
点击查看大图
图(8) / 表(3)
计量
- 文章访问数: 311
- HTML全文浏览量: 86
- PDF下载量: 19
- 被引次数: 0
