三种典型岩石单轴抗压强度的尺寸效应试验研究

王连山; 孙东生; 郑秀华; 赵卫华; 李阿伟; 李全

三种典型岩石单轴抗压强度的尺寸效应试验研究

王连山^{1, 2,},
孙东生^{1, 3, ,},
郑秀华²,
赵卫华^{1, 3},
李阿伟^{1, 3},
李全^{1, 3}

1.
中国地质科学院地质力学研究所, 北京 100081
2.
中国地质大学(北京)工程技术学院, 北京 100083
3.
国土资源部新构造运动与地质灾害重点实验室, 北京 100081

基金项目:

国家自然科学基金项目 41404080

国土资源部公益性行业专项 201211076

详细信息

作者简介:
王连山(1991-), 男, 硕士研究生, 主要从事岩土工程领域相关工作。E-mail:wls@cugb.edu.cn

通讯作者:
孙东生(1980-), 男, 博士, 高级工程师, 主要从事原地应力测量、岩石力学试验方面的研究。E-mail:dongshengsun@cags.ac.cn

中图分类号: TU452
计量
- 文章访问数: 945
- HTML全文浏览量: 178
- PDF下载量: 52
- 被引次数: 0
出版历程
- 收稿日期: 2016-06-01
- 刊出日期: 2017-04-01

SIZE EFFECT EXPERIMENT OF UNIAXIAL COMPRESSIVE STRENGTH OF THREE TYPICAL ROCKS

WANG Lian-shan^{1, 2
,},
SUN Dong-sheng^{1, 3
, ,},
ZHENG Xiu-hua²,
ZHAO Wei-hua^{1, 3},
LI A-wei^{1, 3},
LI Quan^{1, 3}

1.
Institute of Geomechanics, Chinese Academy of Geological Sciences, Beijing 100081, China
2.
School of Engineering and Technology, China University of Geosciences, Beijing 100083, China
3.
Key Laboratory of Neotectonic Movement & Geohazard, Ministry of Land and Resources, Beijing 100081, China

摘要

摘要: 尺寸效应是岩石力学领域研究的难点与热点。本文利用自主研发的大尺寸刚性试验机，开展了最大样品尺寸为400 mm×400 mm×800 mm大理岩、闪长岩和凝灰岩的单轴抗压强度试验，从等高宽比条件下岩石强度的尺寸效应和不同高宽比条件下岩石强度变化两个方面开展了岩石强度尺寸效应研究，结果表明：相同高宽比条件下，岩石强度随样品尺寸的增大呈对数形式减小，且逐渐趋于定值；不同高宽比情况，岩石长宽为200 mm×200 mm，高度分别为200 mm，400 mm，600 mm和800 mm，岩石单轴抗压强度随高宽比的增加表现出先减小后增大的变化规律，对应的破坏形式表现为复杂劈裂、劈裂和剪切破坏。本文试验结果为丰富岩石尺寸效应研究提供了基础数据，同时对实际工程中岩体强度尺寸效应的修正具有一定参考价值。
- 大尺寸岩石 /
- 单轴抗压强度 /
- 尺寸效应 /
- 高宽比 /
- 破坏形式
Abstract: Size effect is a popular and difficult issue in the field of rock mechanics. In this paper, the uniaxial compressive strength of marble, diorite and tuffsamples with the maximum sample size 400 mm×400 mm×800 mm were tested using the self-developed large-scale rigid testing machine. Two cases of size effect of rock uniaxial compression strength were conducted:one is with the same aspect ratio and the other is different aspect ratio with the same length and width. The results show that, with the increase of samples dimensions, the uniaxial compression strength decrease in logarithmic function form and gradually approach to a certain value in the case that with the same aspect ratio; In the case that with different aspect ratios, the length and width of the samples are 200 mm×200 mm, and the heights are 200 mm, 400 mm, 600 mm and 800 mm respectively. The uniaxial compression strength decreased first and then increased as the increase of aspect ratio of samples. And the corresponding failure modes of samples are complex splitting, splitting and shear failure respectively as the increase of aspect ratio. The results of uniaxial compression strength of different dimensions presented in this paper provide the basic data for the size effect research of rock samples. At the same time, the results have some reference value for the correction of size effect in the practical engineering.
- large-size rock /
- uniaxial compressive strength /
- size effect /
- aspect ratio /
- failure mode

HTML全文

图 1 样品显微薄片照片(正交偏光)

a-大理石；b-闪长石；c-凝灰石
Qtz-石英；Dol-白云石；Mus-白云母；Fsp-长石；Bit-黑云母；Hb-角闪石

Figure 1. Microstructure photo of rock samples (crossed polars)

下载: 全尺寸图片幻灯片

图 2 10000 kN室内双轴加载装置

Figure 2. 10000 kN indoor biaxial loading device

下载: 全尺寸图片幻灯片

图 3 三种岩石平均抗压强度尺寸效应拟合曲线

Figure 3. Fitting curves of average compressive strength size effect of three kinds of rocks

下载: 全尺寸图片幻灯片

图 4 不同宽高比条件下岩石单轴抗压强度(样品长宽为200mm×200mm)

Figure 4. Uniaxial compressive strength with different aspect ratio

下载: 全尺寸图片幻灯片

图 5 三种岩石不同高宽比破坏形式对比图

Figure 5. The different failure mode contrast photos of three kinds of rocks with the different aspect ratios

下载: 全尺寸图片幻灯片

表 1 各个尺寸岩样的力学参数

Table 1. The mechanical parameters of each sample size

试验类型	样品长×宽×高/ mm	UCS/MPa
试验类型	样品长×宽×高/ mm	大理岩	闪长岩	凝灰岩
等高宽比	25×25×50	95.9	120.5	131.7
	50×50×100	74.2	104.1	116.9
	100×100×200	48.6	75.2	99.6
	200×200×400	13.8	37.2	53.0
	300×300×600	31.6	55.9	57.2
	400×400×800	51.0	47.1	54.2
不同高宽比	200×200×200	59.1	72.8	67.7
	200×200×400	13.8	37.2	53.0
	200×200×600	31.1	65.5	21.0
	200×200×800	47.9	103.3	64.0
	UCS：岩石的单轴抗压强度

下载: 导出CSV

参考文献(21)

[1]	唐军峰, 徐国元, 唐雪梅, 等.复杂开挖条件下大断面洞室围岩的变形及力学特性研究[J].地质力学学报, 2009, 15(3): 233~244. http://journal.geomech.ac.cn/ch/reader/view_abstract.aspx?flag=1&file_no=20090304&journal_id=dzlxxb TANG Jun-feng, XU Guo-yuan, TANG Xue-mei, et al. Deformation and mechanical properties of the large underground cavern surrounding rock with complex excavation[J]. Journal of Geomechanics, 2009, 15(3): 233~244. http://journal.geomech.ac.cn/ch/reader/view_abstract.aspx?flag=1&file_no=20090304&journal_id=dzlxxb
[2]	汪吉林, 姜波, 王超勇.矿井构造应力场的模拟研究-以鲍店煤矿为例[J].地质力学学报, 2007, 13(3): 239~246. http://journal.geomech.ac.cn/ch/reader/view_abstract.aspx?flag=1&file_no=20070331&journal_id=dzlxxb WANG Ji-lin, JIANG Bo, WANG Chao-yong.Simulation study of the tectonic stress field in mines-a case study of the Baodian coal mine[J]. Journal of Geomechanics, 2007, 13(3): 239~246. http://journal.geomech.ac.cn/ch/reader/view_abstract.aspx?flag=1&file_no=20070331&journal_id=dzlxxb
[3]	曾立新.深层岩石力学性质的试验方法[J].地质力学学报, 1999, 5(1): 71~75. http://journal.geomech.ac.cn/ch/reader/view_abstract.aspx?flag=1&file_no=19990113&journal_id=dzlxxb ZENG Li-xin.Laboratory test method study of deep rock physical mechanics[J]. Journal of Geomechanics, 1999, 5(1): 71~75. http://journal.geomech.ac.cn/ch/reader/view_abstract.aspx?flag=1&file_no=19990113&journal_id=dzlxxb
[4]	尤明庆, 邹友峰.关于岩石非均质性与强度尺寸效应的讨论[J].岩石力学与工程学报, 2000, 19(3): 391~395. http://www.cnki.com.cn/Article/CJFDTOTAL-YSLX200003031.htm YOU Ming-qing, ZOU You-feng.Discussion on heterogeneity of rockmaterial and size effect on specimen strength[J]. Chinese Journal of Rock Mechanics and Engineering, 2000, 19(3): 391~395. http://www.cnki.com.cn/Article/CJFDTOTAL-YSLX200003031.htm
[5]	Hudson J A, Crouch S L, Fairhurst C. Soft, stiff and servo-controlled testing machines:a review with reference to rock failure[J]. Engineering Geology, 1972, 6(3): 155~189. doi: 10.1016/0013-7952(72)90001-4
[6]	刘宝琛, 张家生, 杜奇中, 等.岩石抗压强度的尺寸效应[J].岩石力学与工程学报, 1998, 17(6): 611~614. http://www.cnki.com.cn/Article/CJFDTOTAL-DZLX201702017.htm LIU Bao-chen, ZHANG Jia-sheng, DU Qi-zhong, et al.A study of size effect for compression strength of rock[J]. Chinese Journal of Rock Mechanics and Engineering, 1998, 17(6): 611~614. http://www.cnki.com.cn/Article/CJFDTOTAL-DZLX201702017.htm
[7]	尤明庆, 华安增.岩样单轴压缩的尺度效应和矿柱支承性能[J].煤炭学报, 1997, 22(1): 37~41. http://www.cnki.com.cn/Article/CJFDTOTAL-MTXB701.007.htm YOU Ming-qing, HUA An-zeng.The size effect of uniaxial compression of rock specimen and support capacity of ore pillar[J]. Journal of China Coal Society, 1997, 22(1): 37~41. http://www.cnki.com.cn/Article/CJFDTOTAL-MTXB701.007.htm
[8]	汤大明, 杨寿成.岩石单轴抗压强度的尺寸效应研究[J].四川水力发电, 2011, 30(S1): 119~122, 126. http://www.cnki.com.cn/Article/CJFDTOTAL-SCSL2011S1034.htm TANG Da-ming, YANG Shou-cheng. Scale effect of rock uniaxial compressive strength[J]. Sichuan Water Power, 2011, 30(S1): 119~122, 126. http://www.cnki.com.cn/Article/CJFDTOTAL-SCSL2011S1034.htm
[9]	黄兴益, 田敏.岩石试件尺寸效应与岩体强度的研究[J].云南冶金, 2012, 41(2): 14~18. http://www.cnki.com.cn/Article/CJFDTOTAL-YNYJ201202001.htm HUANG Xing-yi, TIAN Min. Study on size effect of rock sample and rock mass strength[J]. Yunnan Metallurgy, 2012, 41(2): 14~18. http://www.cnki.com.cn/Article/CJFDTOTAL-YNYJ201202001.htm
[10]	陈瑜, 黄永恒, 曹平, 等.不同高径比时软岩强度与变形尺寸效应试验研究[J].中南大学学报(自然科学版), 2010, 41(3): 1073~1078. http://www.cnki.com.cn/Article/CJFDTOTAL-ZNGD201003044.htm CHEN Yu, HUANG Yong-heng, CAO Ping, et al. Size effect experimental study of strength and deformation in different height-to-diameter ratio soft rocks[J]. Journal of Central South University(Science and Technology), 2010, 41(3): 1073~1078. http://www.cnki.com.cn/Article/CJFDTOTAL-ZNGD201003044.htm
[11]	陈鹏, 周志伟.基于RFPA^2D的岩石尺寸效应试验[J].辽宁工程技术大学学报(自然科学版), 2012, 31(6): 842~845. CHEN Peng, ZHOU Zhi-wei.Size effect experiment of rock material with RFPA^2D[J]. Journal of Liaoning Technical University(Natural Science), 2012, 31(6): 842~845.
[12]	朱珍德, 邢福东, 王军, 等.基于灰色理论的脆性岩石抗压强度尺寸效应试验研究[J].岩土力学, 2004, 25(8): 1234~1238. http://www.cnki.com.cn/Article/CJFDTOTAL-YTLX200408014.htm ZHU Zhen-de, XING Fu-dong, WANG Jun, et al. Experimental study on size effect on comperession strength of brittle rock based on grey theory[J]. Rock and Soil Mechanics, 2004, 25(8): 1234~1238. http://www.cnki.com.cn/Article/CJFDTOTAL-YTLX200408014.htm
[13]	杨圣奇, 苏承东, 徐卫亚.岩石材料尺寸效应的试验和理论研究[J].工程力学, 2005, 22(4): 112~118. http://www.cnki.com.cn/Article/CJFDTOTAL-GCLX200504021.htm YANG Sheng-qi, SU Cheng-dong, XU Wei-ya.Experimental and theoretical study of size effect of rock material[J]. Engineering Mechanics, 2005, 22(4): 112~118. http://www.cnki.com.cn/Article/CJFDTOTAL-GCLX200504021.htm
[14]	梁昌玉, 李晓, 张辉, 等.中低应变率范围内花岗岩单轴压缩特性的尺寸效应研究[J].岩石力学与工程学报, 2013, 32(3): 528~536. http://www.cnki.com.cn/Article/CJFDTOTAL-YSLX201303012.htm LIANG Chang-yu, LI Xiao, ZHANG Hui, et al. Research on size effect of uniaxial compression properties of granite under medium and low strain rates[J]. Chinese Journal of Rock Mechanics and Engineering, 2013, 32(3): 528~536. http://www.cnki.com.cn/Article/CJFDTOTAL-YSLX201303012.htm
[15]	倪红梅, 杨圣奇.单轴压缩下岩石材料尺寸效应的数值模拟[J].煤田地质与勘探, 2005, 33(5): 47~49. http://www.cnki.com.cn/Article/CJFDTOTAL-MDKT200505013.htm NI Hong-mei, YANG Sheng-qi.Numerical simulation on size effect of rock material under uniaxial compression[J]. Coal Geology & Exploration, 2005, 33(5): 47~49. http://www.cnki.com.cn/Article/CJFDTOTAL-MDKT200505013.htm
[16]	刘晓红, 赵青山, 陈积光.高径比对板岩单轴抗压强度尺寸效应的试验研究[J].工程勘察, 2015, 43(3): 6~11. http://www.cnki.com.cn/Article/CJFDTOTAL-GCKC201503002.htm LIU Xiao-hong, ZHAO Qing-shan, CHEN Ji-guang.Experimental study on size effect to the uniaxial compressive strength of slate specimen as to the height diameter ratio[J]. Geotechnical Investigation & Surveying, 2015, 43(3): 6~11. http://www.cnki.com.cn/Article/CJFDTOTAL-GCKC201503002.htm
[17]	韩素平, 徐素国.石灰岩单轴压缩尺度效应试验研究[J].矿业研究与开发, 2005, 25(2): 17~20. http://www.cnki.com.cn/Article/CJFDTOTAL-KYYK200502005.htm HAN Su-ping, XU Su-guo.Experimental study on size effect in the uniaxial compression of lime rock[J]. Mining Research & Development, 2005, 25(2): 17~20. http://www.cnki.com.cn/Article/CJFDTOTAL-KYYK200502005.htm
[18]	孙超, 刘芳, 蒋明镜, 等.岩石抗压强度的尺寸效应及端部约束的离散元数值模拟[J].岩石力学与工程学报, 2014, 33(S2): 3421~3428. http://www.cnki.com.cn/Article/CJFDTOTAL-YSLX2014S2006.htm SUN Chao, LIU Fang, JIANG Ming-jing, et al. Size effect of compression strengthand endconstraint of rocks by distinct element simulation[J]. Chinese Journal of Rock Mechanics and Engineering, 2014, 33(S2): 3421~3428. http://www.cnki.com.cn/Article/CJFDTOTAL-YSLX2014S2006.htm
[19]	王学滨, 潘一山, 宋维源.岩石试件尺寸效应的塑性剪切应变梯度模型[J].岩土工程学报, 2001, 23(6): 711~713. http://www.cnki.com.cn/Article/CJFDTOTAL-YTGC200106013.htm WANG Xue-bin, PAN Yi-shan, SONG Wei-yuan.The model of plastic shear strain gradient on size effect in uniaxial compression of rock specimen[J]. Chinese Journal of Geotechnical Engineering, 2001, 23(6): 711~713. http://www.cnki.com.cn/Article/CJFDTOTAL-YTGC200106013.htm
[20]	张后全, 徐建峰, 贺永年, 等.灰岩单轴压缩实验室尺度效应研究[J].岩石力学与工程学报, 2012, 31(S2): 3491~3496. http://www.cnki.com.cn/Article/CJFDTOTAL-YSLX2012S2007.htm ZHANG Hou-quan, XU Jian-feng, HE Yong-nian, et al. Study of laboratoryscale effect of limestone under uniaxial compression[J]. Chinese Journal of Rock Mechanics and Engineering, 2012, 31(S2): 3491~3496. http://www.cnki.com.cn/Article/CJFDTOTAL-YSLX2012S2007.htm
[21]	中华人共和国水利部. SL 264~2001水利水电工程岩石试验规程[S]. 北京: 中国水利水电出版社, 2001. The Ministry of Water Resources of the People's Republic of China.SL 264~2001 Specifications for rock tests in water conservancy and hydroelectric engineering[S]. Beijing: China Water & Power Press, 2001.